Skoda Fabia

Since 2000 of release

Repair and car operation

Shkoda Fabija
+ 1.1. The car description
+ 2. The engine
+ 3. Greasing system
+ 4. The power supply system
+ 5. Cooling system
+ 6. System of release of the fulfilled gases
- 7. Transmission and a running gear
   + 7.1. A transmission
   - 7.2. A forward suspension bracket
      7.2.1. Removal and installation of a telescopic rack
      7.2.2. Repair of a telescopic rack
      7.2.3. Replacement of a spherical support
      7.2.4. Removal and installation of the lever of a forward suspension bracket
      7.2.5. Removal and installation of an arm of a forward suspension bracket
      7.2.6. Replacement резинометаллической support
      7.2.7. Removal and installation of the stabilizer of cross-section stability
   + 7.3. A back suspension bracket
+ 8. A steering
+ 9. Brake system
+ 10. An electric equipment
+ 11. A body
+ 12. Electroschemes

7.2.2. Repair of a telescopic rack

THE GENERAL DATA

Defective амортизаторную it is necessary to replace a rack.

Replacement

PERFORMANCE ORDER

1. Open a cowl, remove a protective cap and ослабьте a nut inhaling, keeping шестигранником a rod from проворачивания. After that remove a rack from the car.

2. Remove a plate 11 (fig. of the Detail of a rack of a forward suspension bracket see) support from a rack.

3. Turn away a nut 2 and take out a bolt 3.

4. Insert the big screw-driver into a cut and accurately unclench a rotary fist 1 in a fastening place амортизаторной racks 4.

5. Remove a rotary fist from a rack.

6. Clamp a rack in a vice so that not to rumple its case.

7. Compress a spring 7 special couplers.

8. Turn away a nut 10 rods of the shock-absorber, keeping шестигранником a rod from проворачивания.

9. Remove a support 9 with the bearing 8.

10. Remove a spring 7.
11. If necessary remove a protective casing 6 with the buffer of 5 compression.
12. Replace the damaged buffer of compression and the protective casing which has burst, torn or lost elasticity.
13. Replace the bearing if it has axial люфт, there are traces подтекания greasings from under protective rings, bearing jamming at проворачивании and corrosion.
14. Replace a spring if on it cracks are found out or coils are deformed. Depending on rigidity of a spring mark a paint. Establish a new spring with the same marks which were on old. If marks on an old spring are not visible, consult at servicing deport Skoda. It is recommended to replace springs from both parties.
15. Establish амортизаторную a rack vertically and some times against the stop lower and lift a shock-absorber rod. Be then convinced that it moves without failures, jammings and knocks. Otherwise replace a rack. It is necessary to replace an amortizatornuju rack and at detection of traces подтекания a liquid and damage of a carving to the top part of a rod.
16. Replace burst, погнутые a support and a plate.
17. Collect a telescopic rack upside-down. Thus replace new nuts of a rod and a coupling bolt.

The inhaling moments, Нм

Nut of a coupling bolt
60, then to tighten on 90

Nut of a rod of the shock-absorber
60